Experimental Evaluation of Free-Fall Gravity Drainage in Water-Drive Reservoirs: Impact of Aquifer Strength and Reservoir Heterogeneity/Homogeneity
Main Article Content
Abstract
This study experimentally investigated Free-Fall Gravity Drainage (FFGD) under combination-drive conditions in a two-dimensional Hele-Shaw model representing a water-drive reservoir. An initially high gravity potential from the oil column enabled early oil drainage before aquifer support became dominant. Three water-drive strengths were tested, demonstrating that a stronger aquifer (1.15 psig) accelerated oil recovery to approximately 75% of the original oil in place (OOIP) within 60 minutes, resulting in a final recovery of 79.5%. However, this was accompanied by rapid water breakthrough after 2.5 minutes and high-water cuts exceeding 90%. In contrast, a weaker aquifer (0.725 psig) stabilized the oil–water contact, delaying water encroachment and maintaining zero water cut throughout 240 minutes, albeit with a lower ultimate recovery of 70.2%. Visual observations confirmed that a stable water crest and oil bank were preserved longer under moderate to weak aquifer pressures, extending the gravity-dominated recovery and reducing water handling requirements. Residual oil saturation was higher under weak aquifer support (27.9%) than stronger water drive (16.8%) due to a loss of gravity potential as the oil column declined and limited aquifer support. A comparative experiment in a heterogeneous system revealed approximately 22% lower ultimate recovery and water breakthrough within 5 minutes, attributed to heterogeneity promoting preferential flow, poor sweep efficiency, and early breakthrough. In contrast, the homogeneous system sustained production with no water breakthrough for 300 minutes. These insights strengthen the understanding of gravity drainage and can help guide enhanced oil recovery strategies in water-drive reservoirs.
Downloads
Article Details
Section
How to Cite
References
Abdulrahman, A.A.A., 2019. An experimental study of fractional wettability effects on gas assisted gravity drainage (GAGD). MSc thesis, Craft & Hawkins Department of Petroleum Engineering, Louisiana State University and Agricultural and Mechanical College, USA.
Ahmed, T., 2019. Reservoir engineering handbook. 5th ed. Elsevier. ISBN: 9780128136492.
Ahmed, T., McKinney, P.D., 2004. Advanced reservoir engineering. 1st ed. Oxford: Gulf Professional Publishing. ISBN: 978-0-7506-7733-2.
Alamooti, A.M. and Malekabadi, F.K., 2018. An introduction to enhanced oil recovery. Fundamentals of enhanced oil and gas recovery from conventional and unconventional reservoirs, pp. 1-40. https://doi.org/10.1016/B978-0-12-813027-8.00001-1.
Al-Mudhafar, W.J., Rao, D.N., Srinivasan, S., 2018. Robust optimization of cyclic CO₂ flooding through the gas-assisted gravity drainage process under geological uncertainties. Journal of Petroleum Science and Engineering, 166, pp. 490–509. https://doi.org/10.1016/j.petrol.2018.03.044.
Al-Obaidi, D., 2020. Feasibility of water sink-based gas flooding to enhance oil recovery in North Rumaila oil field. PhD thesis, Department of Petroleum Engineering, University of Baghdad, Iraq.
Al-Obaidi, D.A., Al-Jawad, M.S., 2020. Numerical simulation of immiscible CO₂-assisted gravity drainage process to enhance oil recovery. Iraqi Journal of Science, 61(8), pp. 2004–2016. https://doi.org/10.24996/ijs.2020.61.8.17.
Al-Obaidi, D.A., Al-Mudhafar, W.J., Al-Jawad, M.S., 2022. Experimental evaluation of carbon dioxide-assisted gravity drainage process (CO₂-AGD) to improve oil recovery in reservoirs with strong water drive. Fuel, 324. https://doi.org/10.1016/j.fuel.2022.124409.
Al-Obaidi, D.A., Al-Mudhafar, W.J., Al-Jawad, M.S., 2024. Experimental influence assessments of water drive and gas breakthrough through the CO₂-assisted gravity drainage process in reservoirs with strong aquifers. Fuel, 370. https://doi.org/10.1016/j.fuel.2024.131873.
Dumore, J.M., Schols, R.S., 1974. Drainage capillary-pressure functions and the influence of connate water. Soc Pet Eng AIME J, 14(5), pp. 437–444. https://doi.org/10.2118/4096-pa.
Dykstra, H., 1978. The prediction of oil recovery by gravity drainage. Journal of Petroleum Technology, 30(05), pp. 818–830. https://doi.org/10.2118/6548-PA.
Dzulkarnain, I., 2018. Investigation of flow mechanisms in gas-assisted gravity drainage process. PhD thesis, Department of Petroleum Engineering, Louisiana State University, USA.
Erfani, H., Rasouli, V., Aminian, K., Smith, J.E., 2021. Experimental and modelling study of gravity drainage in a three-block system. Transport in Porous Media, 136(2), pp. 471–494. https://doi.org/10.1007/s11242-020-01521-x.
Ezeaneche, O.S., Onyia, C.A., Enweremadu, C.C., Udeh, N.E., 2021. Gravity drainage system: investigation and field development using geological modelling and reservoir simulation. SPE Nigeria Annual International Conference and Exhibition 2021. https://doi.org/10.2118/207117-MS.
Hagoort, J., 1980. Oil recovery by gravity drainage. Society of Petroleum Engineers Journal, 20(03), pp. 139-150. https://doi.org/10.2118/7424-PA.
Hasanzadeh, M., Jamialahmadi, M., Müller-Steinhagen, H., 2021a. New insights into forced and free fall gravity drainage performance in a fractured physical model. Journal of Petroleum Science and Engineering, 203. https://doi.org/10.1016/j.petrol.2021.108568.
Jadhawar, P.S. and Sarma, H.K., 2012. Effect of well pattern and injection well type on the CO2-assisted gravity drainage enhanced oil recovery. Journal of Petroleum Science and Engineering, 98, pp. 83-94. https://doi.org/10.1016/j.petrol.2012.09.004.
Joshi, S.D., 1991. Horizontal well technology. Tulsa, OK: PennWell Publishing Company. ISBN: 9780878143504.
Lewis, J.O., 1942. Gravity drainage in oil fields. Transactions of the AIME, 155(1), pp. 133–146. https://doi.org/10.2118/944133-G.
Mahmoud, T.N. and Rao, D.N., 2007, November. Mechanisms and performance demonstration of the gas-assisted gravity-drainage process using visual models. In SPE Annual Technical Conference and Exhibition, pp. SPE-110132. SPE. https://doi.org/10.2118/110132-MS.
Mahmoud, T.N. and Rao, D.N., 2008. Range of operability of gas-assisted gravity drainage process. In SPE Improved Oil Recovery Conference, pp. SPE-113474. SPE. https://doi.org/10.2118/113474-MS.
Mello, S.F. de, Trevisan, O.V., Schiozer, D.J., 2009. Review on gravity drainage performance. In: Proceedings of the 20th International Congress of Mechanical Engineering (COBEM 2009), November 15–20, Gramado, RS, Brazil.
Moghaddam, M.B., Rasaei, M.R., 2015. Experimental study of the fracture and matrix effects on free-fall gravity drainage with micromodels. SPE Journal, 20(02), pp. 324–336. https://doi.org/10.2118/171555-PA.
Muskat, M., 1949. Physical principles of oil production. McGraw-Hill Book Co. ISBN: 978-0-934634-07-6.
Oliviera, I.B., Demond, A.H., Salehzadeh, A., 1996. Packing of sands for the production of homogeneous porous media. Soil Science Society of America Journal, 60(1), pp. 49–53. https://doi.org/10.2136/SSSAJ1996.03615995006000010010X.
Rao, D.N., Girard, M., Lee, J.I., 2004. Development of gas-assisted gravity drainage (GAGD) process for improved light oil recovery. SPE Annual Technical Conference.
Rao, D.N., Ayirala, S.C., Kulkarni, M.M. and Sharma, A.P., 2004, April. Development of gas assisted gravity drainage (GAGD) process for improved light oil recovery. In SPE Improved Oil Recovery Conference? pp. SPE-89357. SPE. https://doi.org/10.2118/89357-MS.
Rao, D.N., 2012. Gas-assisted gravity drainage (GAGD) process for improved oil recovery. U.S. Patent 8,215,392 B2, issued July 10, 2012. https://patents.google.com/patent/US8215392B2/en
Ren, W., Bentsen, R.G. and Cunha, L.B., 2005. A study of the gravity assisted tertiary gas injection processes. Journal of Canadian Petroleum Technology, 44(02). https://doi.org/10.2118/05-02-02.
Rostami, B., Ayatollahi, S., Rashidi, F., 2010. Gas-oil relative permeability and residual oil saturation as related to displacement instability and dimensionless numbers. Oil and Gas Science and Technology, 65(2), pp. 299–313. https://doi.org/10.2516/ogst/2009038.
Ruiz Paidin, W., 2006. Physical model study of the effects of wettability and fractures on gas assisted gravity drainage (GAGD) performance. MSc thesis, Department of Petroleum Engineering, Louisiana State University, USA.
Schechter, D.S. and Guo, B., 1996, March. Mathematical modeling of gravity drainage after gas injection into fractured reservoirs. In SPE Permian Basin Oil and Gas Recovery Conference, pp. SPE-35170. SPE. https://doi.org/10.2118/35170-MS
Sharma, A.P., 2005. Physical model experiments of the gas-assisted gravity drainage process. MSc thesis, Department of Petroleum Engineering, Louisiana State University and Agricultural and Mechanical College, USA.
Sharma, A.P., Rao, D.N., 2008. Scaled physical model experiments to characterize the gas-assisted gravity drainage EOR process. In Proceedings of the 2008 SPE/DOE Improved Oil Recovery Symposium. Tulsa, OK, USA, pp. 773–795. https://doi.org/10.2118/113424-MS.